张冲,赵强,高树永,李延钊,安卫民,刘志远
ZHANG Chong,ZHAO Qiang,GAO Shuyong,Li Yanzhao,AN Weimin,LIU Zhiyuan

• 1:国网内蒙古东部电力有限公司内蒙古超特高压分公司

摘要(Abstract)：

针对某厂站300 Mvar空冷调相机转子一点接地导致的跳闸故障，通过现场检查、返厂拆解、化学成分分析、力学性能测试、金相组织分析、断口形貌分析、温度场仿真等手段对故障原因进行了详细分析。结果表明，连接螺钉压紧区域附近处的引线与绝缘盒之间存在悬空区域，需要使用绝缘配垫进行填充，而装配过程中绝缘配垫未能完全充实该区域，导致引线悬空，引线在离心力的长期作用下最终发生断裂。为此，建议对转子引线绝缘配垫结构进行优化，加强装配工序质量控制，明确工艺质量标准和检查标准，以避免同类型故障再次发生。
Aiming at the fault of the rotor of 300 Mvar air-cooled synchronous condenser in a plant, the author analyzes the cause of the fault in detail by field inspection, disassembly, chemical composition analysis, mechanical property test,metallographic structure analysis, fracture morphology analysis, temperature field simulation and other relevant simulations and tests. The results indicate that there is a suspended area between the lead and the insulation box near the compression area of the connecting screw, which requires to be filled with insulation pads. However, during the assembly process, the insulation pads do not fully fill the area, resulting in the lead being suspended and eventually breaking under the long-term action of centrifugal force. Therefore, it is recommended to optimize the insulated gasket structure of rotor leads and strengthen the quality control of the assembly process, clarify the process quality standards and inspection standards, and avoid the recurrence of similar faults.

关键词(KeyWords)： 调相机;转子一点接地;绝缘配垫;温度场仿真;引线断裂
synchronous condenser;rotor one-point grounding;insulated gasket;temperature field simulation;lead fracture

Abstract:

Keywords:

基金项目(Foundation):

作者(Author): 张冲,赵强,高树永,李延钊,安卫民,刘志远
ZHANG Chong,ZHAO Qiang,GAO Shuyong,Li Yanzhao,AN Weimin,LIU Zhiyuan

参考文献(References)：

• [1]王若愚，蔡京陶，叶键民，等.STATCOM与新型调相机在交直流受端系统中的暂态特性对比研究[J].广东电力，2021,34(2):77-83.WANG Ruoyu,CAI Jingtao,YE Jianmin,et al.Comparative Study on Transient Characteristics of STATCOM and New Condenser in AC/DC Receiving Terminal System[J].Guangdong Electric Power,2021,34(2):77-83.
• [2]慕腾，邢华栋，杨志国，等.同步调相机应用于内蒙古电网的仿真分析[J].内蒙古电力技术，2021,39(6):11-15.MU Teng,XING Huadong,YANG Zhiguo,et al.Simulation analysis of synchronous compensator applicated in Inner Mongolia power grid[J].Inner Mongolia Electric Power,2021,39(6):11-15.
• [3]肖繁，王涛，高扬，等.基于特高压交直流混联电网的调相机无功补偿及快速响应机制研究[J].电力系统保护与控制，2019,47(17):93-100.XIAO Fan,WANG Tao,GAO Yang,et al.Research on reactive power compensation and fast response mechanism of synchronous condenser based on UHVAC/DC hybrid grid[J].Power System Protection and Control,2019,47(17):93-100.
• [4]郭琪，张爱军，刘石川，等.同步调相机接入对电网特性影响分析[J].内蒙古电力技术，2022,40(3):59-62.GUO Qi,ZHANG Aijun,LIU Shichuan,et al.Influence analysis of synchronous condenser accessed on power grid characteristics[J].Inner Mongolia Electric Power,2022,40(3):59-62.
• [5]张涛，赵晋泉.基于IFAHP和TOPSIS的直流弱送端电网调相机配置方案综合评估[J].电测与仪表，2021,58(4):107-114.ZHANG Tao,ZHAO Jinquan.Comprehensive evaluation of synchronous condenser configuration scheme for weak sendingend HVDC power grid based on IFAHP and TOPSISmethod[J].Electrical Measurement&Instrumentation,2021,58(4):107-114.
• [6]李斌.抽水蓄能发电电动机组转子绕组典型绝缘故障分析[J].内蒙古电力技术，2019,37(6):26-29.LI Bin.Typical Insulation Fault Analysis on Rotor Winding of Pumped-Storage Generation Unit[J].Inner Mongolia Electric Power,2019,37(6):26-29.
• [7]胡昌雄，李冬.隔河岩电厂3号发电机转子一点接地案例分析[J].水电与新能源，2020,34(5):74-75,78.HU Changxiong,LI Dong.Case Study of a One-point Grounding Fault of Generator Rotor in No.3 Unit in Geheyan Hydropower Plant[J].Hydropower and New Energy,2020,34(5):74-75,78.
• [8]金炜，郭贤珊.国家电网有限公司防止调相机事故措施及释义[M].北京：中国电力出版社，2021.
• [9]李志祥，罗仁彩，艾远高,等.大中型水轮发电机组电气设备维护技术[M].北京：中国三峡出版社，2020.
• [10]电力行业继电保护标准化技术委员会.同步调相机控制保护系统技术导则：DL/T2250-2021[S].北京：中国电力出版社，2021．
• [11]李玉平，桑建斌，朱宇聪，等.基于双端直流注入切换采样原理的发电机转子接地保护[J].电力系统自动化，2020,44(21):139-144.LI Yuping,SANG Jianbin,ZHU Yucong,et al.Earth fault protection for generator rotor based on switching sampling principle with double-end DC injection[J].Automation of Electric Power Systems,2020,44(21):139-144.
• [12]陈春茂.大型发电机组转子一点接地保护的研究[D].南京：东南大学，2019.
• [13]山东电力研究院.大型调相机运行维护培训教材[M].北京：中国电力出版社，2018.
• [14]郭智琳.应用于特高压交直流混联电网的大容量调相机配置与保护研究[D].北京：北京交通大学，2022.
• [15]李静，舒鹏.藏中地区负荷增长对西藏主电网电压稳定影响分析[J].东北电力技术，2022,43(7):23-25.LI Jing,SHU Peng.Analysis of Load Growth to Influence of Tibet′s Main Power Grid Stable Voltage in Central Tibet[J].Northeast Electric Power Technology,2022,43(7):23-25.
• [16]李伟，杨晓辉，徐大鹏，等.基于补偿短路的汽轮发电机转子匝间短路RSO测试方法[J].内蒙古电力技术，2021,39(2):7-10.LI Wei,YANG Xiaohui,XU Dapeng,et al.RSO Test Method of Turbo-Generator Rotor Interturn Short Circuit Based on Short Circuit Compensation[J].Inner Mongolia Electric Power,2021,39(2):7-10.
• [17]俞卫新，王晓剑，何天磊，等.重复脉冲法在发电机转子一点接地故障诊断中的研究与应用[J].大电机技术，2021(6):22-27.YU Weixin,WANG Xiaojian,HE Tianlei,et al.Research and Application of Repetitive Surge Oscillograph Method in Onepoint Ground Fault Diagnosis of Generator Rotor Winding[J].Large Electric Machine and Hydraulic Turbine,2021(6):22-27.
• [18]岳啸鸣，屈少平，曹杰，等.汽轮发电机转子匝间短路RSO检测应用浅析[J].大电机技术，2019,264(3):32-37.YUE Xiaoming,QU Shaoping,CAO Jie,et al.The application research on RSO detection of turbo-generator rotor inter-turn short circuit[J].Large Electric Machine and Hydraulic Turbine,2019,264(3):32-37．
• [19]电力行业电机标准化技术委员会.隐极同步发电机转子匝间短路故障诊断导则：DL/T 1525-2016[S].北京：中国电力出版社，2016．
• [20]郭杨，陈昊，刘学权，等.特高压换流站调相机转子接地保护跳闸分析与改进[J].电力安全技术，2023,25(8):49-53.GUO Yang,CHEN Hao,LIU Xuequan,et al.Analysis and Improvement of a Rotor Grounding Protection Trip of Synchronous Condenser in an UHV Converter Station[J].Electric Safety Technology,2023,25(8):49-53.