种佳丽,车传强,王琼,赵磊,王磊,赵俊,冯汝明
CHONG Jiali,CHE Chuanqiang,WANG Qiong,ZHAO Lei,WANG Lei,ZHAO Jun,FEGN Ruming

• 1:内蒙古电力(集团)有限责任公司内蒙古电力科学研究院分公司
• 2:内蒙古自治区高电压与绝缘技术企业重点实验室

摘要(Abstract)：

建立500 k V金属氧化物避雷器（Metal Oxidation Arrester,MOA）的三维模型，对不同污秽状态下的MOA进行静电场仿真计算，探究内部电场及电压分布的变化规律。计算结果表明，均匀干污秽状态下的MOA与清洁状态下的MOA差异很小，不会影响设备正常运行；均匀湿污秽状态下的MOA不同位置电阻片所承担的电压差异非常大，会加速电阻片劣化，缩短MOA运行寿命；整体不均匀污秽状态下的MOA内部电场强度大幅度增加，易出现局部放电，进而加速电阻片和瓷套劣化；局部不均匀污秽状态下的MOA内部电场强度非常大，特别是在均压环泵和最上部法兰电压为597 kV的极端情况下，氮气绝缘层的绝缘强度已远远不够，会发生绝缘击穿，损坏设备。
To establish a three-dimensional model of 500 kV metal oxide arrester(MOA), perform electrostatic field simulation calculation for MOA in different filthy states, and explore the changed rule of internal electric field and voltage distribution.The calculation results show that there is little difference between the MOA in uniform dry and dirty state and the MOA in clean state, which will not affect the normal operation of the equipment. In the condition of uniform wet pollution, the voltage difference of the resistance pieces at different positions of MOA is very large, which will accelerate the deterioration of the resistance pieces and shorten the operating life of MOA. The internal electric field intensity of MOA in the overall non-uniform pollution state increases greatly, and partial discharge is easy to occur. The internal electric field intensity of MOA in the state of local uneven pollution is very large. In extreme cases, the insulation strength of the nitrogen insulation layer is far from enough, resulting in the insulation breakdown and the damage of the device.

关键词(KeyWords)： 金属氧化物避雷器;污秽;电场强度;电压分布
metal oxide arrester(MOA);filth;electric field strengthintensity;voltage distribution

Abstract:

Keywords:

基金项目(Foundation): 内蒙古电力（集团）有限责任公司内蒙古电力科学研究院分公司青年科技人员支持计划项目“氧化物避雷器现场精测带电测试技术研究”（2021-QK-06）

作者(Author): 种佳丽,车传强,王琼,赵磊,王磊,赵俊,冯汝明
CHONG Jiali,CHE Chuanqiang,WANG Qiong,ZHAO Lei,WANG Lei,ZHAO Jun,FEGN Ruming

参考文献(References)：

• [1]刘尉，肖集雄，金硕，等.基于场路耦合的500 kV氧化锌避雷器受潮缺陷分析[J].电瓷避雷器，2022(1):118-125.LIU Wei,XIAO Jixiong,JIN Shuo,et al.Analysison Damp Defect of 500 kV Zinc Oxide Arrester Based on Field-Circuit Coupling[J].Insulators and Surge Arresters,2022(1):118-125.
• [2]田晓云，范永强，艾博，等.500 kV线路金属氧化物避雷器缺陷分析及处理[J].内蒙古电力技术，2021,39(1):98-100.TIAN Xiaoyun,FAN Yongqiang,AI Bo,et al.Analysis and Treatment of 500 kV Metal Oxide Arrester Defects[J].Inner Mongolia Electric Power,2021,39(1):98-100.
• [3]叶涛.变电站避雷器故障原因分析及解决措施[J].内蒙古电力技术，2015,33(6):93-96,100.YE Tao.Cause Analysis and Solving Measures on Breakage Failure of Arrester in Substation[J].Inner Mongolia Electric Power,2015,33(6):93-96,100.
• [4]郭秉义，杨文惠，赵勇，等.变电站500 kV避雷器故障原因分析及预防措施[J].内蒙古电力技术，2015,33(1):26-29.GUO Bingyi,YANG Wenhui,ZHAO Yong,et al.Cause Analysis and Preventive Measures of Substation 500 kV Surge Arrester Failure[J].Inner Mongolia Electric Power,2015,33(1):26-29.
• [5]李谦，江宇栋，赵晓凤，等.连续雷击引发无间隙金属氧化物避雷器热崩溃的仿真分析[J].电瓷避雷器，2022(5):73-78.LI Qian,JIANG Yudong,ZHAO Xiaofeng,et al.Simulation Analysis of Non-Gap Metal Oxide Surge Arresters Thermal Breakdown Caused by Continuous Lightning Strikes[J].Insulators and Surge Arresters,2022(5):73-78.
• [6]余凯.污秽绝缘子表面电场仿真分析[J].通信电源技术，2018,35(4):33-34,37.YU Kai.Simulation Analysis of Surface Electric Field of Dirty Insulator[J].Telecom Power Technologies,2018,35(4):33-34,37.
• [7]刘宗喜，蓝磊，陈胤，等.复合材料杆塔污秽条件下局部放电试验及电场仿真研究[J].绝缘材料，2017,50(1):61-67.LIU Zongxi,LAN Lei,CHEN Yin,et al.Partial Discharge Test and Electric Field Simulation of Polluted Composite Material Tower[J].Insulating Materials,2017,50(1):61-67.
• [8]陈世群，张诏昌，叶旭岚，等.考虑污秽电流的避雷器在线监测系统的设计和应用[J].电工技术，2021(23):155-158.CHEN Shiqun,ZHANG Zhaochang,YE Xulan,et al.Design and Application of On-line Monitoring System for Lightning Arresters Considering Pollution Current[J].Electric Engineering,2021(23):155-158.
• [9]黄强，陈锦浩.污秽条件下10 kV带间隙避雷器闪络现象分析[J].电工技术，2020(5):111-112.HUANG Qiang,CHEN Jinhao.Analysis of Flashover Phenomenon of 10 kV Air-gapped Arresters under Polluted Condition[J].Electric Engineering,2020(5):111-112.
• [10]周挺，唐信.特高压直流极母线避雷器污秽状况下内外部电场分布的仿真研究[J/OL].电测与仪表:1-6[2023-02-07].http://kns.cnki.net/kcms/detail/23.1202.th.20210107.1642.018.html.
• [11]赵隆，黄新波，赵钰，等.考虑外表面污秽影响的避雷器在线监测技术[J].电气自动化，2019,41(3):112-114,118.ZHAO Long,HUANG Xinbo,ZHAO Yu,et al.On-line Monitoring Technology for Arresters Considering Affection of Filth on Their External Surface[J].Electrical Automation,2019,41(3):112-114,118.
• [12]朱传华，李威，刘长青.10 kV避雷器的污闪试验及防治措施[J].大众用电，2019,34(7):38-39.ZHU Chuanhua,LI Wei,LIU Changqing.Pollution flashover test and prevention measures of 10 kV lightning arrester[J].Popular Utilization of Electricity,2019,34(7):38-39.
• [13]杨毅，胡军，梁振.不同污秽浓度下10 kV氧化锌避雷器联合加压试验研究[J].电气应用，2019,38(6):70-76.YANG Yi,HU Jun,LIANG Zhen.Experimental study on combined pressurization of 10 kV zinc oxide surge arrester under different contaminant concentrations[J].Electrical Application,2019,38(6):70-76.
• [14]杨雅倩，罗日成，郭天伟，等.特高压氧化锌避雷器电场分布计算[J].高压电器，2019,55(2):1-7.YANG Yaqian,LUO Richeng,GUO Tianwei,et al.Analysis on Electric Field Calculation of UHV Zn O Surge Arrester[J].High Voltage Apparatus,2019,55(2):1-7.
• [15]刘博垚，徐建源，高强，等.特高压交流氧化锌避雷器电位分布仿真计算与分析[J].高压电器，2018,54(5):156-160,168.LIU Boyao,XU Jianyuan,GAO Qiang,et al.Simulation and Analysis of the Potential Distribution of UHVAC Zn O Surge Arrester[J].High Voltage Apparatus,2018,54(5):156-160,168.
• [16]张迪，张丕沛，张军阳，等.基于ANSYS的1000 kV金属氧化物避雷器不同运行状况下电位分布的仿真计算[J].高电压技术，2018,44(5):1660-1667.ZHANG Di,ZHANG Pipei,ZHANG Junyang,et al.Simulation Calculation of Potential Distribution of 1000 kV Metal Oxide Arrester Under Different Conditions Using ANSYS[J].High Voltage Engineering,2018,44(5):1660-1667.
• [17]张丕沛，苗世洪，钟丹田，等.基于ANSYS的500 kV金属氧化物避雷器不同运行状况下电位分布的仿真计算[J].电瓷避雷器,2017(6):26-31.ZHANG Pipei,MIAO Shihong,ZHONG Dantian,et al.Simulation Calculation of Potential Distribution of 500 kV Metal Oxide Arrester Under Different Conditions by Using ANSYS[J].Insulators and Surge Arresters,2017(6):26-31.
• [18]孙浩，李兴文.500 kV瓷套式氧化锌避雷器电位分布的有限元分析与实验研究[J].高压电器，2010,46(3):23-27.SUN Hao,LI Xingwen.Finite Element Calculation and Experiment of Potential Distribution for a 500 kV Porcelain Zinc Oxide Arrester[J].High Voltage Apparatus,2010,46(3):23-27.
• [19]刘家豪.500 kV避雷器不同污秽状况下径向电场及电压分布的仿真研究[J].电瓷避雷器，2021(1):45-50.LIU Jiahao.Simulation of Radial Electric Field and Voltage Distribution of 500 kV MOA Under Different Pollution Conditions[J].Insulators and Surge Arresters,2021(1):45-50.
• [20]何金龙.煤矿供电系统避雷性能改进[J].机电工程技术，2020,49(5):234-236.HE Jinlong.Improvement of Lightning Protection Performance of Power Supply System in Coal Mine[J].Mechanical&Electrical Engineering Technology,2020,49(5):234-236.
• [21]邓超平.66 kV金属氧化避雷器故障分析及防范措施[J].内蒙古电力技术，2019,37(2):88-92.DENG Chaopoing.Fault Analysis and Improvement Measures on 66 kV Metal Oxide Arrester[J].Inner Mongolia Electric Power,2019,37(2):88-92.
• [22]王磊，赵子建，白洁，等.220 kV氧化锌避雷器受潮故障诊断分析及处理[J].内蒙古电力技术，2023,41(1):61-65.WANG Lei,ZHAO Zijian,BAI Jie,et al.Diagnosis Analysis and Treatment of 220 kV Zinc Oxide Arrester Damped Defect[J].Inner Mongolia Electric Power,2023,41(1):61-65.